Previous Thread
Next Thread
New Reply
Print Thread
Rate Thread

Joined: Oct 2003
Posts: 1,061
Specialist
2001 Toyota Celica GT
Specialist
2001 Toyota Celica GT
Joined: Oct 2003
Posts: 1,061
[Linked Image]

Custom Suede Headliner
By Jon (carbon_blue_gt)


Before you begin, make sure that you have the following:

** A yard and a half (60" wide) of the fabric of your choice. I used black polyester suede. Price will vary by fabric and location. (a great place to get started at is http://www.joann.com )

** 3M General Trim Adhesive n. 08088
Approximately $11.00 at Checker Schucks, Kragen, Pepboys, Autozone or Home Depot.

** A flexible plastic paint guide
$.79 each at Wal-Mart (may be handy to have two or three in case one gets glue on it

** a friend


Step 1)
First, you need to remove the headliner. It's helps to have the back seats folded down for this. Pull the covers off the A-pillars, remove the dome light housing and unplug it. (also a good time to paint it!!) Remove the screws that hold the sunshades up, and unscrew the sunshade latches. These take a little effort to pull out once they are unscrewed, but do not fear, they are almost indestructible (as far as I cal tell).


Next, unscrew the top seatbelt guide (behind the front seats). Pull this panel away from the frame and set these aside. There are also three pins across the back of the headliner; pry these off carefully with a flathead screwdriver. Next, there are two plastic screw-rivets (one on each side) they are located just behind the front seat on the roof, they're black, and hard to miss. Take these out, and the headliner should pretty much fall down (you may have to gently pull the edges away from the weather-stripping around the door.


Now, carefully lift it out of the hatch.



Step 2)
Find a good, large, clean area to work, and cover it with plastic; this can get messy.


Lay the headliner face up on the table


[Linked Image]



Next, spray the 3M adhesive on a strip about 6 inches wide down the middle of the headliner. Make sure you get good coverage.


Have a friend hold the material up above the headliner while you use the plastic paint guide to smooth the material onto the glue. Don't use too much pressure, because you could force the glue through the cloth. Smooth away from the middle, being sure not to get any creases or bunches in the cloth.


After a couple of minutes set time, pull the material back so that you can spray one of the sides that does not yet have glue on it. Spray the adhesive, and repeat the process of smoothing (with your friend holding the fabric again). Make sure that you smooth around the complex curves of the headliner first, then stretch the fabric away from that. This allows the fabric to conform to the curves.


Continue with this until the fabric has been glued down on the entire surface ot the headliner.


[Linked Image]

[Linked Image]

[Linked Image]

[Linked Image]

[Linked Image]

[Linked Image]



Step 3)
After the glue has had a night to set up, turn the headliner over. Cut some slits in the fabric to make it easier to wrap around the edge. Use your best judgment where these should be, I don't really have any specific way for you to do this. After you've cut the slits, use an industrial strength glue (I used E-6000, available at most hobby shops like Hobby Lobby), and, working in sections, run a bead of glue along the edge of the headliner and fold the fabric over and press it down. Try to make the fabric conform as closely to the edge as possible.


[Linked Image]



Step 4)
Cut holes in the fabric for the dome light, sunvisers, and the clips that hold it up.

Replace the headliner in the car using the opposite of step 1.

Enjoy your newly re-upholstered headliner.

My next guide, "Reupholstering the sunvisors"

Any questions, please feel free to email me at "RaderStudios @ hotmail.com"

Joined: Oct 2003
Posts: 1,061
Specialist
2001 Toyota Celica GT
Specialist
2001 Toyota Celica GT
Joined: Oct 2003
Posts: 1,061
finished, and installed...

[Linked Image]

[Linked Image]

[Linked Image]


[Linked Image]

Joined: Oct 2003
Posts: 1,061
Specialist
2001 Toyota Celica GT
Specialist
2001 Toyota Celica GT
Joined: Oct 2003
Posts: 1,061
I just got a PM from a user who was worried about doing his headliner because of having a moonroof. I reaplied with the following:

Quote
I don't think you should have too much of a problem. Just be careful when you take the headliner down (i don't know what kind of fasteners might be around the moonroof) All you have to do is lay your fabric over the headliner in one piece, glue it down, then go back and cut out the hole for the headliner. Take your time, and be careful, you'll be fine. Good luck, and post pics when you get done thumbsup


I hope this helps some of you out there with moonroofs!


[Linked Image]

Joined: Sep 2003
Posts: 2
New Member
2003 Toyota Celica GT
New Member
2003 Toyota Celica GT
Joined: Sep 2003
Posts: 2
What would you say to wrapping the hoodliner with Kevlar or Carbon Fiber, is it a fairly smooth wrap around the edges?

Joined: Oct 2003
Posts: 1,061
Specialist
2001 Toyota Celica GT
Specialist
2001 Toyota Celica GT
Joined: Oct 2003
Posts: 1,061
You could do it, it's a nice smooth wrap, but I would personally like the feel and look of a fabric interior better...

Last edited by isaac; Sep 11, 2004 5:03pm.

[Linked Image]

Joined: Jan 2004
Posts: 19
Member
2000 Toyota Celica GT
Member
2000 Toyota Celica GT
Joined: Jan 2004
Posts: 19
How do I get the headliner off if I have a moonroof?
Theres a rim that keeps the headliner on, I cant get the rim off. Do you have any suggestions?

Joined: May 2002
Posts: 5,979
Likes: 9
ECelica Admin
2001 Toyota Celica GT
ECelica Admin
2001 Toyota Celica GT
Joined: May 2002
Posts: 5,979
Likes: 9


[Linked Image]
It's not just your imagination...
Your day really does go by twice as fast while on EverythingCelica.com

Joined: May 2004
Posts: 2
New Member
1995 Honda Accord H22a
New Member
1995 Honda Accord H22a
Joined: May 2004
Posts: 2
sweet also if you want to add a decal in it. ALL you do is get thin foam board cut out lets say the toyota symbol and then glu that first then when puttin the suede down you just press around the the foam board. and boom you got a custom look..

Joined: Jan 2005
Posts: 1
New Member
2000 Toyota Celica GT
New Member
2000 Toyota Celica GT
Joined: Jan 2005
Posts: 1
I have a little trouble trying to remove the seatbelt guide and the two plastic panels behind the front seats, can someone give me a tip or a trick to do this?!!!

Last edited by rice_boy; Feb 16, 2005 11:49am.

Joined: Aug 2004
Posts: 12
Member
2000 Toyota Celica
Member
2000 Toyota Celica
Joined: Aug 2004
Posts: 12
hey you could talk to my friends at topshop headliners into making a pure carbon fiber headliner they are already almost done with the cargo cover see look i will show ya the pics of a finished one that is not the celicas but it will look just as good and fit like the original about one more week for ours to finish
1953486877-Picture 157.jpg

Last edited by U12PLA; Feb 17, 2005 9:25pm.

Joined: Aug 2004
Posts: 12
Member
2000 Toyota Celica
Member
2000 Toyota Celica
Joined: Aug 2004
Posts: 12
thsi is TopShops
1953486888-new tag 004.jpg

Joined: Mar 2013
Posts: 1
New Member
New Member
Joined: Mar 2013
Posts: 1
how did you remove the carpet off of it?

Joined: May 2002
Posts: 806
Likes: 15
CelicaSpecialist
2008 Scion tC
CelicaSpecialist
2008 Scion tC
Joined: May 2002
Posts: 806
Likes: 15
Originally Posted by jberlin0
how did you remove the carpet off of it?

The guide describes how to WRAP your current headliner... carpet was covered.

The product from "Topshop" is a replacement headliner... no carpet.

Joined: Nov 2018
Posts: 7
New Member
2000 Toyota Celic GTS
New Member
2000 Toyota Celic GTS
Joined: Nov 2018
Posts: 7
Turning whole inside of my Celica black n’ white with some blue LED for the foot wells, THIS will look amazing with my flocked dash

Join the conversation - Register Now or Log In to add your comment


Link Copied to Clipboard
Member Spotlight
toysport_celica
toysport_celica
2000 Toyota Celica
Ca

Posts: 52
Joined: August 2004
Thank you.: me, myself, and I...!
Random: a bowl of rice, fried chicken, and a glass of water!
Show All Member Profiles 
Recent Topics
Spyder Headlight LEDs
by Dxnxld - Mar 25, 2024 6:51am
Anyone ever hear this noise?
by CeliacCelica - Mar 21, 2024 10:51am
Clunking sound (not sure where from)
by Juliansky - Mar 20, 2024 3:01am
Does anybody know where i can find a S53 trans rebuild kit?
by MoreRamenNoodles - Mar 19, 2024 8:57pm
Urgent
by SoloXKay - Mar 19, 2024 11:58am
OEM speedometer on aftermarket ecu
by Penaman99 - Mar 5, 2024 11:23am
Brake master cylinder
by Nigel100 - Mar 5, 2024 2:45am
newly purchased 2000 GTS
by CantShift - Feb 27, 2024 9:06pm
Customize Your Toyota Celica Privacy Policy · About · Contact
Privacy Policy · About · Contact
CelicaHobby.com is an independent Toyota Celica enthusiast website. CelicaHobby.com is not sponsored by or affiliated with Toyota Motor Sales, USA, Inc. in any way. The Toyota and Celica names and logos are trademarks owned by Toyota Motor Sales, USA, Inc.
© CelicaHobby.com, 2001-2024
Powered by UBB.threads™ PHP Forum Software 8.0.0
(Preview build 20230331)