Previous Thread
Next Thread
New Reply
Print Thread
Rate Thread

Joined: May 2002
Posts: 6,716
Likes: 3
Specialist
year make model & trim
Specialist
year make model & trim
Joined: May 2002
Posts: 6,716
Likes: 3
How To Repair Water Leak / Wet Back Seats
By KidKoala

My girlfriend now owns a Celica VVTI, which is a lovely car but it has suffered with a water ingress / leak problem that took a fair bit of detective work so I thought it is best to write it up.

We first noticed the problem when a friend sat in the back, and got a wet bum!

This car was getting wet on the right hand rear seat behind the driver.

I stripped the interior out, and found a pool of water under the rear bench on the right hand side (unsurprisingly) and the seat foam was pretty wet too.

Searching online was of little use, some suggestions of boot/trunk seals and rear quarter lights.

I put a hose over various bits of the car, and eventually saw water dripping in around the area of the wheel arch, and tracking along the seam sound deadening into the seat base area.


[Linked Image]


After some detective work it was apparent the water was coming in through the tailgate gutter somehow, so I checked the area on the outside to see what could be leaking.

There is a rubber cylindrical bung on the top right hand side of the boot/trunk opening/gutter, and in this case the bung was loose in the hole and able to move around a fair bit. I'm guessing the rubber went hard and shrank over the years.

You could potentially buy a new bung from Toyota, but I wanted an instant fix. I ran some VW sealing cord/putty round the perimeter of the bung, and popped it back in to make a perfect seal.


[Linked Image]


I then used the hose again, and there was much less water ingress, but still it was coming in steadily.

I was out of ideas, so had to strip the rest of the interior out (the plastics around the rear quarter light, and boot/trunk plastics).

I then got my girlfriend to spray the car with the hose, and I sat inside looking for leaks.

About 3" into the width of the rear quarter light (above it) there is a metal seam where 2 skins meet with ridges in it.

Water was leaking between the two seams and coming out of a ridge in a slow drip.

Sorry for the appalling photo, I forgot to take an actual one of the drip at the time.


[Linked Image]


At first I thought maybe it was the quarter-light seal, but just spraying this excessively with the hose showed no signs of water ingress.

I traced the rough path of the water by looking at the arrangement of the panels, and decided the only places it could possibly be coming in from was the roof gutter, where two seems meet in the top right hand corner.

I ran this past my friend who was a Toyota mechanic for a long time, and he said that other Toyota's used to go on this seam, but not the Celica, so I guess this is a rare case but I doubt I'm the only one with the problem (especially as these cars get older).

I have used some brush on seam sealant over the dodgy seam, and will paint it soon so it is inconspicuous.


[Linked Image]


Whilst in the boot/trunk doing all this, I noticed a fair bit of water there too - I traced this back to the boot/trunk seal, which was in great condition but leaking from underneath.

Due to trapped water in here, there was a bit of rust on the lip in various places, so I removed it with a Dremel flap wheel, panel wiped it and then touched it up with Hammerite [hammerite.com] rust prevention and restoration paint. No one sees any of this as the seal/plastics in the boot/trunk cover it all up.


[Linked Image]

[Linked Image]

[Linked Image]

[Linked Image]


Toyota originally sealed these with black silicone from the factory. I pulled the seal off and ran a bead of RTV silicone [google.com] along the lip of the bodywork, then refitted the seal.


[Linked Image]

[Linked Image]


It's mostly back together now, but keeping the seats out to confirm tomorrow with a hose that it's all spot on.


[Linked Image]


Hopefully the car is now leak free, and rust free for another 13 years at least!

SOURCE: http://www.toyotaownersclub.com/for...ta-celica-vvti-water-leak-how-to-repair/


[Linked Image from danasoft.com]

Joined: Aug 2014
Posts: 9
Member
2000 Toyota Celica GT
Member
2000 Toyota Celica GT
Joined: Aug 2014
Posts: 9
Wow, that is determination! Those were tough leaks to find. Thanks for letting us know so we will know where to look if we get a leak.
I had a water leak also. Same thing, wet bum in the back seat. I traced mine to dirt and debris build up at the top of the hatch gasket. I cleaned the rubber seal, cleaned the contact area, then coated everything with silicone water proofing to improve the pliability of the seal and to make sure it was repelling water, not wicking it. The silicone probably coated the rubber bung you mentioned. Either way, it has been six months now with no sign of a wet seat.

Join the conversation - Register Now or Log In to add your comment


Link Copied to Clipboard
Member Spotlight
BLACKGHOST
BLACKGHOST
2003 Toyota Celica GT
IL

Posts: 35
Joined: January 2004
Thank you.: Mama thomas, michelle, mike, scooby,leeo,heavensknight crew westbury,ny
Random: Night time is my time come out and play see ya in the streets.
Show All Member Profiles 
Recent Topics
Spyder Headlight LEDs
by Dxnxld - Mar 25, 2024 6:51am
Anyone ever hear this noise?
by CeliacCelica - Mar 21, 2024 10:51am
Clunking sound (not sure where from)
by Juliansky - Mar 20, 2024 3:01am
Does anybody know where i can find a S53 trans rebuild kit?
by MoreRamenNoodles - Mar 19, 2024 8:57pm
Urgent
by SoloXKay - Mar 19, 2024 11:58am
OEM speedometer on aftermarket ecu
by Penaman99 - Mar 5, 2024 11:23am
Brake master cylinder
by Nigel100 - Mar 5, 2024 2:45am
newly purchased 2000 GTS
by CantShift - Feb 27, 2024 9:06pm
Customize Your Toyota Celica Privacy Policy · About · Contact
Privacy Policy · About · Contact
CelicaHobby.com is an independent Toyota Celica enthusiast website. CelicaHobby.com is not sponsored by or affiliated with Toyota Motor Sales, USA, Inc. in any way. The Toyota and Celica names and logos are trademarks owned by Toyota Motor Sales, USA, Inc.
© CelicaHobby.com, 2001-2024
Powered by UBB.threads™ PHP Forum Software 8.0.0
(Preview build 20230331)